-
●非對稱異性隧道聯絡通道冷凍法(07月24日)
-
●水泥夯土材料抗壓強度試驗及耐(08月25日)
-
●變質巖類順層邊坡破裂跡象及邊(07月25日)
-
●大體積混凝土配合比優化設計在(08月25日)
-
●粉煤灰基超高性能混凝土配合比(07月25日)
-
●地鐵車輛段檢修庫裝配式混凝土(07月24日)
-
●大型十字交叉地鐵車站結構地震(07月25日)
-
●變坡面淺埋偏壓小凈距隧道圍巖(07月24日)
-
●邯鄲富水地層深基坑支護優化和(07月25日)
-
●自密實抑溫防水復合材料在地下(08月25日)
-
●粉煤灰摻量對高層建筑筏板基礎(06月26日)
-
●基于遺傳算法的神經網絡對大體(06月27日)
-
●氯鹽漬土無側限抗壓強度及體變(06月25日)
-
●不同 ZrO2 摻量改性水(06月26日)
-
●非均勻銹蝕對建筑鋼混組合梁承(06月27日)
-
●再生微粉泡沫混凝土力學性能研(06月25日)
-
●堿激發粉煤灰-高爐礦渣粉固化(09月11日)
-
●地鐵車輛段檢修庫裝配式混凝土(07月24日)
-
●昌寧隧道豎井輔助正洞施工技術(07月03日)
-
●堅硬頂板沿空留巷充填體加固技(06月25日)
PDF全文閱讀
王 歡 1 , 翁金紅1 , 王嘉昊2 , 馮 建 1 , 劉娟紅2 , 韓方暉2
( 1 . 安徽馬鋼礦業資源集團姑山礦業有限公司 ,安徽 馬鞍山 243000;
2. 北京科技大學 土木與資源工程學院 ,北京 100083)
摘 要 :本文選取細粒級鐵尾礦粉,并加入改性劑對其進行改性,研究改性鐵尾礦粉的化學及礦物成分、細度 、燒失量 、需水量比及活性指數等相關性能,并與Ⅱ級粉煤灰性能進行比較,探究改性劑對鐵尾礦粉的改性效果和改性機理。研究結果表明:細粒級鐵尾礦粉的化學與礦物組成與粉煤灰相近,細粒級鐵尾礦粉>45 μm 的顆粒含量為 17. 7% 、燒失量為 6. 5% 、改性后需水量比為 97. 2% , 均滿足國家Ⅱ級粉煤灰相關標準 。堿類復合改性劑改性效果最好,改性鐵尾礦粉 3 d 、7 d 和 28 d 活性指數分別為 95. 6% 、95. 7%和 89. 3% , 均高于Ⅱ級粉煤灰。隨著改性鐵尾礦粉比表面積增加,凈漿抗壓強度提高 。鐵尾礦粉經過改性處理后,界面處的 SiO2 中的硅氧鍵會出現重組現象,發生重聚反應,宏觀表現為抗壓強度的提高 。且鐵尾礦粉顆粒粒徑越小,這種重聚反應越顯著,抗壓強度的提升越明顯。
關鍵詞 :鐵尾礦粉 ;粉煤灰 ;改性劑 ;強度 ;改性機理
中圖分類號 :X752
文獻標志碼 :A
文章編號 :1005- 8249 (2023) 05- 0071- 06
DOI : 10. 19860/j . cnki . issn1005- 8249. 2023 . 05 . 012
WANG Huan 1 , WENG Jinhong1 , WANG Jiahao2 , FENG Jian 1 ; LIU Juanhong2 , HAN Fanghui2
( 1 . Anhui Masteel Mining Resources Group Gushan Mining Co. ,Ltd . , Ma ′anshan 243000 , China;
2. School of Civil and Resource Engineering , University of Science and Technology Beijing , Beijing 100083 , China)
Abstract: In this paper, fine-grained iron tailings fines were selected and modified with modifiers. The chemical and mineral composition, fineness, burn-off, water demand ratio and activity index of the modified iron tailings powder were studied. The properties are compared with those of Class II fly ash to investigate the modification effect and modification mechanism of the modifier on the iron tailing powder. The results of the study show that the chemical and mineral composition of fine-grained iron tailings fines is similar to that of fly ash. The fine-grained iron tailings fines have a particle content of >45μm of 17.7% and a burn-off of 6.5%. The water demand ratio after modification was 97.2%, all of which met the relevant national standards for Class II fly ash. The best modification effect was achieved by the alkali composite modifier, with the activity index of modified iron tailing powder being 95.6%, 95.7% and 89.3% at 3d, 7d and 28d respectively, all of which were higher than that of Class II fly ash. As the specific surface area of modified iron tailing powder increased, the compressive strength of net slurry increased. After the modified iron tailing powder is treated, the silica-oxygen bonds in SiO2 at the interface will be reorganised and reunification reaction will occur, which is macroscopically manifested as an increase in compressive strength. The smaller the particle size of iron tailing powder, the more significant this reunification reaction is, and the more obvious the increase of compressive strength.
Keywords: iron tailings; fly ash; modifier; strength; modification mechanism
作者簡介 :王歡 (1989—) , 女 ,碩士研究生 ,高級工程師 ,研究方向 :礦物加工工程。
收稿日期 :2022- 04- 08
- 上一篇:沿海地區地鐵盾構施工注漿材料設計研究
- 下一篇:石膏基保溫砂漿的制備與性能研究
冀公網安備13011002000529 技術支持:數字河北 