-
●非對稱異性隧道聯絡通道冷凍法(07月24日)
-
●水泥夯土材料抗壓強度試驗及耐(08月25日)
-
●變質巖類順層邊坡破裂跡象及邊(07月25日)
-
●大體積混凝土配合比優化設計在(08月25日)
-
●粉煤灰基超高性能混凝土配合比(07月25日)
-
●地鐵車輛段檢修庫裝配式混凝土(07月24日)
-
●大型十字交叉地鐵車站結構地震(07月25日)
-
●變坡面淺埋偏壓小凈距隧道圍巖(07月24日)
-
●邯鄲富水地層深基坑支護優化和(07月25日)
-
●自密實抑溫防水復合材料在地下(08月25日)
-
●粉煤灰摻量對高層建筑筏板基礎(06月26日)
-
●基于遺傳算法的神經網絡對大體(06月27日)
-
●氯鹽漬土無側限抗壓強度及體變(06月25日)
-
●不同 ZrO2 摻量改性水(06月26日)
-
●非均勻銹蝕對建筑鋼混組合梁承(06月27日)
-
●再生微粉泡沫混凝土力學性能研(06月25日)
-
●堿激發粉煤灰-高爐礦渣粉固化(09月11日)
-
●地鐵車輛段檢修庫裝配式混凝土(07月24日)
-
●昌寧隧道豎井輔助正洞施工技術(07月03日)
-
●堅硬頂板沿空留巷充填體加固技(06月25日)
PDF全文閱讀
李國榮1 , 劉玉芝2
( 1 . 楊凌職業技術學院 ,楊凌 712100 ; 2. 楊凌工業園區投資創業服務有限公司 ,楊凌 712100)
摘 要 :為有效降低超輕泡沫混凝土的材料成本,采用 Ⅰ級、 Ⅱ級和Ⅲ級三種不同等級粉煤灰等量替代超輕泡沫混凝土中的高貝利特硫鋁酸鹽水泥,研究不同等級粉煤灰在不同取代率下的超輕泡沫混凝土物理力學性能。結果表明:摻入粉煤灰后可以進一步降低超輕泡沫混凝土的干密度和導熱系數,起到良好的減重和隔熱效果,但同時也會降低超輕泡沫混凝土的強度,增加收縮變形量;采用 Ⅱ級粉煤灰 、取代率為 15% 時,超輕泡沫混凝土的力學性能較佳,干密度 、比強度、導熱系數 、拉伸黏結強度和 28 d 收縮值分別為 302.9kg/cm3 、 1 276. 6 N ·m/kg 、0. 079 1 W/m ·k 、0. 128 MPa 和 2. 93 mm/m。
關鍵詞:超輕泡沫混凝土 ;高貝利特硫鋁酸鹽水泥 ;粉煤灰 ;取代率
中圖分類號:TU528
文獻標志碼:A
文章編號: 1005- 8249 (2025) 01- 0029- 05
DOI:10. 19860/j.cnki.issn1005 - 8249.2025 .01 .006
LI Guorong1 , LIU Yuzhi2
( 1 . Yangling Voactional & Technical College , Yangling 712100 , China;
2. Yangling Industrial Park Investment Venture Service Co. ,Ltd. ,Yangling 712100 , China)
Abstract: In order to effectively reduce the material cost of ultra light foam concrete, three different grades of fly ash, Grade I, Grade II and Grade III, were used to replace the high belite sulphoaluminate cement in ultra light foam concrete equally, and the physical and mechanical properties of different grades of fly ash under different replacement rates were tested. The results show that the addition of fly ash can further reduce the dry density and thermal conductivity of ultra light foam concrete, playing a good role in weight reduction and heat insulation, but it will also reduce the strength of ultra light foam concrete, while increasing the shrinkage deformation; When Grade II fly ash is used and the substitution rate is 15%, the mechanical properties of ultra light foam concrete are better, with dry density, specific strength, thermal conductivity, tensile bond strength and 28 day shrinkage values of 302.9 kg/cm3, 1276.6 N * m/kg, 0.0791 W/m * k, 0.128 MPa and 2.93 mm/m.
Key words: ultralight foam concrete; high belite sulphoaluminate cement; fly ash; Substitution rate
作者簡介: 李國榮 (1984—) , 男 ,碩士, 副教授 ,研究方向 :結構工程。
收稿日期:2023 - 02 - 06
冀公網安備13011002000529 技術支持:數字河北 