-
●關于新廣告法聲明(07月25日)
-
●非對稱異性隧道聯絡通道冷凍法(07月24日)
-
●水泥夯土材料抗壓強度試驗及耐(08月25日)
-
●變質巖類順層邊坡破裂跡象及邊(07月25日)
-
●大體積混凝土配合比優化設計在(08月25日)
-
●粉煤灰基超高性能混凝土配合比(07月25日)
-
●地鐵車輛段檢修庫裝配式混凝土(07月24日)
-
●大型十字交叉地鐵車站結構地震(07月25日)
-
●變坡面淺埋偏壓小凈距隧道圍巖(07月24日)
-
●邯鄲富水地層深基坑支護優化和(07月25日)
-
●自密實抑溫防水復合材料在地下(08月25日)
-
●粉煤灰摻量對高層建筑筏板基礎(06月26日)
-
●基于遺傳算法的神經網絡對大體(06月27日)
-
●氯鹽漬土無側限抗壓強度及體變(06月25日)
-
●不同 ZrO2 摻量改性水(06月26日)
-
●非均勻銹蝕對建筑鋼混組合梁承(06月27日)
-
●再生微粉泡沫混凝土力學性能研(06月25日)
-
●堿激發粉煤灰-高爐礦渣粉固化(09月11日)
-
●地鐵車輛段檢修庫裝配式混凝土(07月24日)
-
●昌寧隧道豎井輔助正洞施工技術(07月03日)
-
●堅硬頂板沿空留巷充填體加固技(06月25日)
PDF全文閱讀
吉俊豪 ,宋少民 ,李 劭 ,彭 天 ,李金君 ,杜若萱 ,趙曉嬌
(北京建筑大學 ,建筑結構與環境修復功能材料北京市重點實驗室 ,北京 100044)
摘 要:采用水泥固化劑和固廢基膠凝材料固化劑分別固化尾泥制備流態固化土,通過流動擴展度、凝結 時間、泌水率、流變性能和無側限抗壓強度試驗,探討水固比 、灰土比 、激發劑摻量和砂土比對尾泥流態固化土的工作性能和力學性能的影響。結果表明:水固比為 0. 62 ~ 0. 69 , 摻量為 7% ~ 11% 水泥固化劑或 15% ~ 17% GC 固化劑,制備尾泥流態固化土 28 d 抗壓強度在 0. 56 ~ 2. 10 MPa , 滿足一般性非結構回填工程;水固比為 0. 62 , 激發劑摻量 20% , 摻入再生細骨料優化顆粒級配并控制砂土比為 0. 3 時,GC 固化劑流態固化土流動擴展度為 265 mm , 28 d 抗壓強度達到 2. 66 MPa , 泌水率低于 3% , 可滿足早強型結構性回填工程;拌合漿體黏度小于 0. 88 Pa ·s , 流態固化土拌合物泌水率較大;提出機制砂洗砂尾泥的流態固化土制備中可控的參數和膠凝材料 摻量。研究成果可為濕法機制砂尾泥再利用提供參考。
關鍵詞:機制砂尾泥 ;流態固化土 ;固廢基膠凝材料 ;流變性能 ;水固比
中圖分類號:TU528
文獻標志碼:A
文章編號: 1005- 8249 (2025) 02- 0018- 07
DOI:10. 19860/j.cnki.issn1005 - 8249.2025 .02.004
JI Junhao , SONG Shaomin , LI Shao , PENG Tian , LI Jinjun , DU Ruoxuan , ZHAO Xiaojiao
(Beijing University of Civil Engineering and Architecture , Beijing Key Laboratory of Building Structure and
Environmental Remediation Functional Materials , Beijing 100044)
Abstract:Fluidized solidified soil was prepared by stabilizing tailings sludge using cement curing agents and solid waste-based cementitious curing agents, respectively. The effects of water-solid ratio, binder-soil ratio, activator dosage, and sand-soil ratio on the workability and mechanical properties of the fluidized solidified tailings sludge were investigated through experiments on flow spread, setting time, bleeding rate, rheological properties, and unconfined compressive strength. The results indicate that: With a water-solid ratio of 0.62-0.69 and a dosage of 7%-11% cement curing agent or 15%-7% GC curing agent, the 28days strength of the fluidized solidified tailings sludge ranges from 0.56 to 2.10 MPa, meeting the requirements for general non-structural backfill engineering. For GC-cured fluidized soil optimized with a water-solid ratio of 0.62, 20% activator dosage, and controlled sand-soil ratio of 0.3 (incorporating recycled fine aggregates to improve particle gradation), the flow spread reaches 265 mm, the 28days strength attains 2.66 MPa, and the bleeding rate remains below 3%, fulfilling the criteria for early-strength structural backfill applications. When the viscosity of the mixed slurry is less than 0.88 Pa·s, the fluidized solidified soil mixture exhibits a higher probability of bleeding. Controllable parameters and recommended binder dosages for preparing fluidized solidified soil from machine-made sand washing tailings are proposed, providing references for diverse engineering scenarios.
Key words:tailings of mechanically crushed sand;flowable fill or self-compacting backfill;full waste-based cementitious materials;rheological properties;water-to-solid ratio
作者簡介: 吉俊豪 (1998—) , 男,碩士研究生,研究方向:建筑材料。
通信作者:宋少民 (1965—) , 男,碩士,教授,研究方向:現代混凝土材料。
收稿日期:2024 - 10 - 17
冀公網安備13011002000529 技術支持:數字河北 